Monday, July 25, 2011

How to Replace a Manual Transmission?

Remove the shift knob and console trim plate.

Secure your vehicle on a level surface, making sure your car will not roll or lean too much when jacked up.

Use a jack to lift up the front of your vehicle.

Secure the vehicle with jack stands on both sides for safety before starting any work. Do not rely on the jack to hold the vehicle up while working.

Disconnect the speedometer cable. Label wire connectors for installation reference and remove them from the transmission unit.

Remove the driveshaft.

Support the transmission with a jack. Remove the transmission mounts and cross member.

Remove the shift levers from the side of the transmission.

Disconnect the back drive rod from the bell crank.

Remove the bolts from the shift control assembly and carefully lower the assembly until the shift lever clears the rubber shift boot. Then remove the assembly from the car.

Remove the transmission-to-bell housing bolts and remove the transmission from the car.

Lift the transmission and insert the main shaft into the bell housing.

Install and torque the transmission-to-clutch housing bolts.

Install the shift lever and side cover.

Connect the back drive rod to the bell crank.

Install the cross member and transmission mounts.

Install the driveshaft.

Connect the speedometer cable and wiring.

Fill the transmission with the specified fluid type and quantity, install the console trim and shift knob. Adjust the linkage.


For more car related problem troubleshooting:---

This are the sections, you can go through and click the link to read its troubleshooting.


The car will not start?


Car will not crank?


Car has no spark?


How to troubleshoot car battery?


How to test starter solenoid?


How to test cars starter?

How to replace starter in car?


car will turn over but will not start?


The Brake Indicator Light Stays On dash of car?

The ABS and Traction Control Lights stays ON dash of car?

Check Engine Light On car?


How to replace Interior Lights on car?

Car lights not working, even after replacing the bulb/lamp?

Click this link below:--


How to replace head lights on car?


How to replace Parking, turn, and Brake Lights on car?
How to remove the door panel on car?

How to replace power window motor in car?

How to test relays on car?


How to troubleshoot Engine Misfires?


The spark plug firing order for car?


Where is the Thermostat located in car?

How to recharge AC on Auto/Truck/car?


How to trouble shoot speedometer?

To Order car parts online:--To get heavy discount on car parts .Click this link below:----

How to Replace Coil Springs?

How to Replace an Oil Pan Gasket?

How to Replace a Fuel Injector

How to Replace a C.O.P. Type Ignition Coil?

How to Replace a Fuel Pressure Regulator?

How to Replace a Fuel Pump?

How to Replace a Rear Lift Gate Locking Mechanism?

How to Clean a Fuel System

How to Replace an Ignition Coil

How to Replace a Windshield

How to Replace a Mass Air Flow Sensor

How to Replace a Rear Distance Sensor

How to Replace a Muffler

How to Replace an Engine

How to Replace an Intake Manifold Gasket

How to Replace an Oil Pump

How to Lubricate a Brake Pedal Linkage ?

How to Replace a Windshield Wiper Motor

How to Replace a Distributor Cap

How to Replace a Door Weather Stripping

How to Replace a Freeze Plug

How to Replace a Head Gasket

How to Replace a Heater Core

How to Replace Spark Plugs?

How to Replace a Rear Axle Bearing?

No comments:

Post a Comment