Thursday, September 22, 2011

How to replace heater core on Audi ?

Removal & Installation



  1. Disconnect the negative battery cable.
  2. Drain the engine coolant.
  3. Completely remove the instrument panel.
  4. From the engine compartment, label and remove all hoses and necessary wiring.
  5. Remove and plug all A/C lines.
  6. Remove and plug the coolant lines for the heater core.
  7. On Passat models using a heater core that is not completely surrounded by the air box housing, remove the self tapping screws if installed, then slide the heater core out of the housing.
  8. On A4 and Passat models with the heater core installed into the housing:
    1. Remove the heater box housing which contains the evaporator.
    2. Unclip the heater core box.
    3. Remove the heater core.

  9. Installation is the reverse of removal. Always make sure all seals are installed properly during the installation process.
  10. On Passat models using a heater core that is not completely surrounded by the air box housing, install the heater core with a self adhesive seal installed along the top of the fins on the side of the heater core that is near the inlet and outlet spigots and around the end of the heater core spigot housing to seal the heater core in the housing. If the heater core fit is slightly loose, secure it to the housing with self-tapping screws.
  11. If disassembled, seal all seams of the heater box with RTV.
  12. The balance of the installation is in reverse order of removal making sure to have a MVAC certified technician evacuate and recharge the A/C system.


NOTE
Consult the under hood label for the correct refrigerant type and amount installed in the system. The R134A type of refrigerant was introduced as standard equipment in the 1993 models.

A4 And TT



  1. Perform the Output Diagnostic Test Mode (DTM) using the VAG 1551 function 03 by performing the following procedure:
    NOTE
    If equipped with power seats, move the seats as far rearward as possible. Also, obtain the anti-theft radio coding and the preset radio stations from the owner.



    Once the air flow flap closes, cancel the Output DTM by pressing the -C- button.

  2. Discharge and recover the air conditioning system refrigerant.
  3. Remove or disconnect the following:

    Air plenum cover, the water guide and the dust/pollen filter, located at the right side
    Negative battery cable
    Positive battery cable and remove the battery
    Coolant recovery tank cap to relieve the pressure from the system

  4. Drain the cooling system into a clean container for reuse.
  5. Label and disconnect or clamp off the heater hoses from (at) the heater core.
  6. Place a container under the right heater core tube, induce pressurized air to the left tube and blow compressed into the tube to drain excess coolant.
  7. Remove or disconnect the following:

    Air conditioning system vacuum supply hose and attach it at the heater core inlet/outlet
    Heater core-to-chassis boot
    Refrigerant lines-to-evaporator core clamp bolt, disconnect the refrigerant line clamp and discard the O-rings. Plug the openings to prevent contamination.
    Evaporator core-to-chassis boot
    Low pressure switch electrical connector and secure it to the evaporator fixture

  8. Remove the glove box, the driver-s side lower shelf and the instruments panel center section by removing or disconnecting the following:

    5 glove box-to-instrument panel bolts and the glove box
    3 clips, remove the 3 stowage compartment bolts and the stowage compartment at the driver-s side
    Rear console
    3 the knobs, remove the 4 center instrument panel trim bolts, the 2 screws and the trim
    Radio
    4 front console-to-instrument panel bolts
    Trim cover and the console-to-chassis nut at the left side of the front console
    Pedal assembly at the driver-s side

  9. Place the front wheels in the straight-ahead position.
  10. Remove the driver-s side air bag module by removing or disconnecting the following:

    Air bag module-to-steering wheel screws using a T30 Torx bit; the screws are located on both sides of the steering wheel
    Air bag module and disconnect the electrical connector
    Place the air bag module in a safe place with the front facing upward.

  11. Remove the steering wheel by removing or disconnecting the following:

    Steering wheel nut
    Horn and air bag electrical connectors
    4 carrier unit-to-steering wheel bolts and the carrier unit
    Steering wheel

  12. At the steering column-to-instrument panel connection, secure the steering column wire to keep the steering column from sliding apart.
  13. Remove or disconnect the following:

    Steering column-to-steering gear bolt
    Electronic box electrical connectors located in the left air plenum chamber
    All instrument panel-to-chassis electrical connectors

  14. Remove the instrument panel by removing or disconnecting the following:

    Instrument panel-to-chassis bolts
    Any necessary electrical connectors
    Instrument panel

  15. Remove or disconnect the following:

    Ducts, heater/air conditioning housing assembly-to-chassis bolts and the assembly
    Heater core-to-heater/air conditioning housing screws
    Press the heater core-to-heater housing catches and remove the heater core from the heater/air conditioning housing

    Click image to see an enlarged view

    Fig. Exploded view of the air bag module, steering wheel and related components-A4



    Click image to see an enlarged view

    Fig. Exploded view of the rear console assembly-A4



    Click image to see an enlarged view

    Fig. Exploded view of the front console assembly-A4



    Click image to see an enlarged view

    Fig. Exploded view of the instrument panel assembly-A4



    Click image to see an enlarged view

    Fig. Exploded view of the heater core, heater/air conditioning housing and related components-A4



    Click image to see an enlarged view

    Fig. Removing the heater core-A4



To install:

  1. Install or connect the following:

    Heater core to the heater/air conditioning housing and press the heater core into heater housing until the latches catch
    Heater core-to-heater/air conditioning housing screws
    Heater/air conditioning housing assembly and connect the ducts

  2. Install the instrument panel by installing or connecting the following:

    Instrument panel
    Any necessary electrical connectors
    Instrument panel-to-chassis bolts and torque the bolts to 44 inch lbs. (5 Nm)
    All instrument panel-to-chassis electrical connectors
    Electronic box electrical connectors located in the left air plenum chamber
    Steering column-to-steering gear bolt

  3. Install the steering wheel by installing or connecting the following:

    Steering wheel
    Carrier unit and the 4 carrier unit-to-steering wheel bolts
    Horn and air bag electrical connectors
    Steering wheel nut

  4. Install the driver-s side air bag module by installing or connecting the following:

    Air bag module and connect the electrical connector
    Torque the air bag module-to-steering wheel screws to 53 inch lbs. (6 Nm) using a T30 Torx bit; the screws are located on both sides of the steering wheel
    Pedal assembly at the driver-s side

  5. Install the glove box, the driver-s side lower shelf and the instruments panel center section by installing or connecting the following:

    Console-to-chassis nut and the trim cover at the left side of the front console. Torque the nut to 31 inch lbs. (3.5 Nm)
    4 front console-to-instrument panel bolts and torque the bolts to 44 inch lbs. (5 Nm)
    Radio
    4 center instrument panel trim, the 4 center instrument panel trim bolts, the 2 screws and the 3 the knobs. Torque the bolts to 44 inch lbs. (5 Nm) and the screws to 31 inch lbs. (3.5 Nm)
    Rear console
    Stowage compartment, the 3 stowage compartment bolts and engage the 3 clips. Torque the bolts to 44 inch lbs. (5 Nm)
    Glove box and the 5 glove box-to-instrument panel bolts; then, torque the bolts to 44 inch lbs. (5 Nm)

  6. Install or connect the following:

    Low pressure switch electrical connector
    Evaporator core-to-chassis boot.
    Refrigerant lines-to-evaporator core clamp and connect the refrigerant line clamp bolt making sure to use new O-rings
    Heater core-to-chassis boot
    Air conditioning system vacuum supply hose
    Heater hoses to the heater core

  7. Refill the cooling system.
  8. Install the coolant recovery tank cap.
  9. Install the battery and connect the positive (+) battery cable.
  10. Connect the negative (() battery cable.
  11. At the right side, install the dust/pollen filter, the water guide and the air plenum cover.
  12. Evacuate, charge and leak test the air conditioning system.
  13. Operate the engine to normal operating temperature; then, check the climate control operation and check for leaks.

A6




NOTE
If equipped with power seats, move the seats as far rearward as possible. Also, acquire the anti-theft radio coding from the owner.

  1. Remove or disconnect the following:
    NOTE
    If desired, instead of draining cooling system, disconnect heater hoses from tubes in engine compartment and apply compressed air to upper tube and catch coolant from heater core coming out of bottom tube.



    Negative battery cable
    Positive battery cable and remove the battery
    Coolant recovery tank cap to relieve the pressure from the system
    Coolant
    Heater hoses from (at) the heater core
    Heater core tubes-to-chassis grommet

  2. Remove the storage compartment on driver-s side.
  3. From inside passenger compartment, remove bolts and brackets from heater core tubes.
  4. Slightly pull the heater core from the A/C-heater housing.
  5. Pull two coolant lines out of the heater core.
  6. Remove the heater core.
  7. If the heater core cannot be pulled out of the A/C housing, loosen the instrument panel cross member by removing or disconnecting the following:

    Bolt at base of windshield (above meter cluster)
    Loosen RH panel cross member bolts
    Two bolts from bottom of instrument panel brace
    ECM cover
    Pedal bracket from cross member
    LH instrument panel cover (push in steering column as far as possible)
    Loosen 2 LH instrument panel nuts

  8. Pull back instrument panel and cross member enough to allow heater core to be removed.

To install:

  1. Installation is the reverse of the removal procedure, noting the following:

    Install new clamps and O-rings at all connections
    Before installing storage compartment on driver-s side, check for cooling system leaks
    Ensure WOT stop of accelerator pedal is incorrect position


A8



Driver-s Side
  1. Disconnect the negative battery cable.
  2. Turn the ignition switch OFF.
  3. Remove the windshield.
  4. Remove the cowl panel.
  5. Drain the cooling system into the clean container for reuse.
  6. Remove or disconnect the following:

    Engine-to-pump valve unit heater hoses. Drain and plug the openings
    Electrical connectors from the pump valve unit

  7. Remove the reinforcement plate (plenum) by removing or disconnecting the following:

    Remove the intake hose from the air filter.
    At the front wall of the plenum, remove the sound proofing mat.
    Remove the reinforcement plate (plenum)-to-chassis nuts/bolts and the plenum

  8. Remove or disconnect the following:

    Loosen the heater hose holder screw in the plenum about 2 turns

  9. Remove the knee bar by removing or disconnecting the following:

    Open the glove box
    2 knee bar trim screws
    4 knee bar screws
    Pull out the knee bar and disengage the latch
    Electrical connector and remove the knee bar

  10. Remove or disconnect the following:

    Left support bolts and the retainer bolts; then, remove the left support and the retainer
    Center console side trim
    Passenger-s footwell air outlet
    Passenger-s side heater hose clamps, move the heater hoses toward the plenum and discard the O-rings
    Passenger-s side heater core-to-heater case clamp screws and the clamp
    Passengers side heater core
    Driver-s side shelf and center console-s side trim
    Loosen the heater hose holder screws about 2 turns at the driver-s side heater core
    Driver-s side footwell air outlet
    Driver-s side heater hose clamps, move the heater hoses toward the plenum and discard the O-rings
    Driver-s side heater core through the passenger-s side of the heater housing


To install:

  1. Install or connect the following:

    Driver-s side heater core through the passenger-s side of the heater housing
    Move the heater hoses away from the plenum and install the driver-s side heater hose clamps using new O-rings
    Driver-s side footwell air outlet
    Heater hose holder screws at the driver-s side heater core
    Driver-s side shelf and center console-s side trim
    Passenger-s side heater core
    Heater core-to-heater case clamp and the clamp screws
    Heater hoses to the plenum using O-rings and install the passenger-s side heater hose clamps
    Footwell air outlet
    Center console side trim

  2. Install the knee bar by installing or connecting the following:

    Left support and the retainer and the left support bolts and the retainer bolts; then, torque the bolts to 16 ft. lbs. (22 Nm)
    Electrical connector and install the knee bar
    Knee bar and engage the latch
    4 knee bar screws and torque to 22 inch lbs. (2.5 Nm)
    2 knee bar trim screws and torque to 22 inch lbs. (2.5 Nm)

  3. In the plenum, tighten the heater hose holder screw.
  4. Install the reinforcement plate (plenum) by installing or connecting the following:

    Reinforcement plate (plenum) and the plenum-to-chassis nuts/bolts
    Sound proofing mat at the front wall of the plenum
    Intake hose to the air filter.

  5. Install or connect the following:

    Electrical connectors to the pump valve unit
    Engine-to-pump valve unit heater hoses

  6. Refill the cooling system.

    Cowl panel
    Windshield

  7. Connect the negative battery cable.
  8. Operate the engine to normal operating temperature; then, check the climate control operation and check for leaks.

Passenger-s Side
  1. Disconnect the negative battery cable.
  2. Turn the ignition switch OFF.
  3. Remove the cowl panel.
  4. Drain the cooling system into the clean container for reuse.
  5. Remove or disconnect the following:

    Engine-to-pump valve unit heater hoses. Drain and plug the openings
    Electrical connectors from the pump valve unit

  6. Remove the reinforcement plate (plenum) by removing or disconnecting the following:

    Intake hose from the air filter
    Sound proofing mat at the front wall of the plenum
    Reinforcement plate (plenum)-to-chassis nuts/bolts and the plenum
    In the plenum, loosen the heater hose holder screw about 2 turns

  7. Remove the knee bar by removing or disconnecting the following:

    Open the glove box
    2 knee bar trim screws
    4 knee bar screws
    Pull out the knee bar and disengage the latch
    Electrical connector and remove the knee bar

  8. Remove or disconnect the following:

    Left support bolts and the retainer bolts; then, remove the left support and the retainer
    Center console side trim.
    Footwell air outlet

  9. Place an absorbent cover on the floor of the car, under the heater core to catch any spilt coolant.

    Passenger-s side heater hose clamps, move the heater hoses toward the plenum and discard the O-rings
    Heater core-to-heater case clamp screws and the clamp
    Heater core

    Click image to see an enlarged view

    Fig. Exploded view of the glove box, knee bar assembly and related components-A8



    Click image to see an enlarged view

    Fig. Exploded view of the heater cores and related components-A8



To install:

  1. Install or connect the following:

    Heater core
    Heater core-to-heater case clamp and the clamp screws
    Heater hoses to the plenum (using O-rings) and install the passenger-s side heater hose clamps
    Footwell air outlet
    Center console side trim

  2. Install the knee bar by installing or connecting the following:

    Left support and the retainer and the left support bolts and the retainer bolts; then, torque the bolts to 16 ft. lbs. (22 Nm)
    Electrical connector and install the knee bar
    Knee bar and engage the latch
    4 knee bar screws and torque to 22 inch lbs. (2.5 Nm)
    2 knee bar trim screws and torque to 22 inch lbs. (2.5 Nm)
    Tighten the heater hose holder screw in the plenum

  3. Install the reinforcement plate (plenum) by installing or connecting the following:

    Reinforcement plate (plenum) and the plenum-to-chassis nuts/bolts
    Sound proofing mat at the front wall of the plenum
    Intake hose to the air filter
    Electrical connectors to the pump valve unit
    Engine-to-pump valve unit heater hoses

  4. Refill the cooling system.
  5. Install the cowl panel.
  6. Connect the negative battery cable.


--------------

For more car related problem troubleshooting:---

This are the sections, you can go through and click the link to read its troubleshooting.

---------

The car will not start?

http://schematicsdiagram.blogspot.com/2011/06/car-will-not-start.html

-----------------

Car will not crank?

http://schematicsdiagram.blogspot.com/2011/06/car-will-not-crank.html

-----------

Car has no spark?

http://schematicsdiagram.blogspot.com/2011/06/car-has-no-spark.html

-------------

How to troubleshoot car battery?

http://schematicsdiagram.blogspot.com/2011/06/how-to-troubleshoot-car-battery.html

-----------------

How to test starter solenoid?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-starter-solenoid.html

--------------------

How to test cars starter?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-cars-starter.html

How to replace starter in car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-starter-in-car.html

-----------

car will turn over but will not start?

http://technoanswers.blogspot.com/2011/05/car-will-turn-over-but-will-not-start.html

-----------------

The Brake Indicator Light Stays On dash of car?

http://schematicsdiagram.blogspot.com/2011/06/brake-indicator-light-stays-on-dash-of.html

The ABS and Traction Control Lights stays ON dash of car?

http://schematicsdiagram.blogspot.com/2011/06/abs-and-traction-control-lights-stays.html

Check Engine Light On car?

http://schematicsdiagram.blogspot.com/2011/06/check-engine-light-on-car.html

-------------------------

How to replace Interior Lights on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-interior-lights-on-car.html

Car lights not working, even after replacing the bulb/lamp?

Click this link below:--

http://schematicsdiagram.blogspot.com/2011/06/car-lights-not-working-even-after.html

---------------

How to replace head lights on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-head-lights-on-car.html

--------------------

How to replace Parking, turn, and Brake Lights on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-parking-turn-and-brake.html
How to remove the door panel on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-remove-door-panel-on-car.html

How to replace power window motor in car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-power-window-motor-in.html

How to test relays on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-relays-on-car.html

-----------------------------

How to troubleshoot Engine Misfires?

http://schematicsdiagram.blogspot.com/2011/06/how-to-troubleshoot-engine-misfires.html

------------

The spark plug firing order for car?

http://schematicsdiagram.blogspot.com/2011/06/spark-plug-firing-order-for-car.html

------------------------

Where is the Thermostat located in car?

http://schematicsdiagram.blogspot.com/2011/06/where-is-thermostat-located-in-car.html

How to recharge AC on Auto/Truck/car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-recharge-ac-on-autotruckcar.html

-------------------

How to trouble shoot speedometer?

http://schematicsdiagram.blogspot.com/2011/06/speedometer-not-working.html

To Order car parts online:--To get heavy discount on car parts .Click this link below:----

http://technoanswers.blogspot.com/2011/05/from-where-to-order-car-parts-online.html

How to Replace Coil Springs?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-coil-springs.html

How to Replace an Oil Pan Gasket?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-oil-pan-gasket.html

How to Replace a Fuel Injector

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fuel-injector.html

How to Replace a C.O.P. Type Ignition Coil?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-cop-type-ignition-coil.html

How to Replace a Fuel Pressure Regulator?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fuel-pressure-regulator.html

How to Replace a Fuel Pump?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fuel-pump.html

How to Replace a Rear Lift Gate Locking Mechanism?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-lift-gate-locking.html

How to Clean a Fuel System

http://schematicsdiagram.blogspot.com/2011/07/how-to-clean-fuel-system.html

How to Replace an Ignition Coil

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-ignition-coil.html

How to Replace a Windshield

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield.html

How to Replace a Mass Air Flow Sensor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-mass-air-flow-sensor.html

How to Replace a Rear Distance Sensor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-distance-sensor.html

How to Replace a Muffler

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-muffler.html

How to Replace an Engine

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-engine.html

How to Replace an Intake Manifold Gasket

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-intake-manifold-gasket.html

How to Replace an Oil Pump

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-oil-pump.html

How to Lubricate a Brake Pedal Linkage ?

http://schematicsdiagram.blogspot.com/2011/07/how-to-lubricate-brake-pedal-linkage.html

How to Replace a Windshield Wiper Motor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield-wiper-motor.html

How to Replace a Distributor Cap

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-distributor-cap.html

How to Replace a Door Weather Stripping

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-door-weather-stripping.html

How to Replace a Freeze Plug

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-freeze-plug.html

How to Replace a Head Gasket

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-head-gasket.html

How to Replace a Heater Core

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-heater-core.html

How to Replace Spark Plugs?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-spark-plugs.html

How to Replace a Rear Axle Bearing?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-axle-bearing.html

How to Replace a Front Bumper Cover

http://technoanswers.blogspot.com/2011/07/how-to-replace-front-bumper-cover.html

How to Replace a Manual Transmission

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-manual-transmission.html

How to Replace a Headlight Bulb

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-headlight-bulb.html

How to Replace a Headlight Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-headlight-switch.html

How to Replace Windshield Wiper Blades

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield-wiper-blades.html

How to Replace a Cooling Fan

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-cooling-fan.html

How to Replace a Catalytic Converter

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-catalytic-converter.html

How to Replace an Engine Mount

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-engine-mount.html

How to Replace a Fog Light Assembly

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fog-light-assembly.html

How to Change Engine Oil and Filter

http://schematicsdiagram.blogspot.com/2011/07/how-to-change-engine-oil-and-filter.html

How to Replace a Power Seat Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-seat-switch.html

How to Replace a Rear Main Seal

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-main-seal.html

How to Repair a Defroster Grid

http://schematicsdiagram.blogspot.com/2011/07/how-to-repair-defroster-grid.html

How to Replace an AWD Transfer Case

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-awd-transfer-case.html

How to Replace a Plastic License Plate Bracket?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-plastic-license-plate.html

How to Replace a Power Seat Motor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-seat-motor.html

How to Replace Power Steering Fluid

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-steering-fluid.html

How to Replace a Power Window Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-window-switch.html

How to Replace a Quarter Glass Panel?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-quarter-glass-panel.html

How to Pressure Test a Radiator and Cap

http://schematicsdiagram.blogspot.com/2011/07/how-to-pressure-test-radiator-and-cap.html

How to Replace a Radiator

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-radiator.html

How to Repair a Hood.

http://schematicsdiagram.blogspot.com/2011/07/how-to-repair-hood.html

How to Replace an Energy Absorber

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-energy-absorber.html

How to Replace Heater Core Hoses

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-heater-core-hoses.html

How to Replace a Thermostat.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-thermostat.html

How to Rotate Tires.

http://schematicsdiagram.blogspot.com/2011/07/how-to-rotate-tires.html

How to Replace Wheel Lug Nuts

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-wheel-lug-nuts.html

How to Replace a Tire Valve Stem

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-tire-valve-stem.html

How to Change a Flat Tire

http://schematicsdiagram.blogspot.com/2011/07/how-to-change-flat-tire.html

How to Replace Leaf Springs

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-leaf-springs.html

How to Replace a Heater Control Valve

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-heater-control-valve.html

How to Replace Transmission Cooler Lines

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-transmission-cooler.html

How to Replace an Ignition Control Unit

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-ignition-control-unit.html

How to Replace a Brake Hose

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-brake-hose.html

How to Replace a Transfer Case Rear Output Seal

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-transfer-case-rear.html

How to Replace a Seat Belt and Seatbelt Retractor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-seat-belt-and-seatbelt.html

How to Replace a Power Steering Rack

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-steering-rack.html

How to Bleed Brakes with a Tool

http://schematicsdiagram.blogspot.com/2011/07/how-to-bleed-brakes-with-tool.html

How to Replace a Tail Light Bulb

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-tail-light-bulb.html

How to Check Automatic Transmission Fluid Level

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-automatic-transmission.html

How to Change Automatic Transmission Fluid and Filter

http://schematicsdiagram.blogspot.com/2011/07/how-to-change-automatic-transmission.html

How to Replace Vacuum Hoses

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-vacuum-hoses.html

How to Replace an Air Intake Boot

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-air-intake-boot.html

How to Replace a Valve Cover Gasket

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-valve-cover-gasket.html

How to Replace a Water Pump

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html

How to Replace a Windshield Wiper Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield-wiper-switch.html

How to Replace Window Run Channel Seals

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-run-channel-seals.html

How to Replace a Window Regulator

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-regulator.html

How to Balance a Tire and Wheel

http://schematicsdiagram.blogspot.com/2011/07/how-to-balance-tire-and-wheel.html

How to Replace a Window Motor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-motor.html

How to Adjust a Hood Release Latch?

http://schematicsdiagram.blogspot.com/2011/07/how-to-adjust-hood-release-latch.html

How to Replace a Radiator Support

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-radiator-support.html

How to Replace a Rear Pinion Seal.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-pinion-seal.html

How to Replace Battery Cables

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-battery-cables.html

How to Replace a Proportioning Valve

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-proportioning-valve.html

How to Replace an Upper Radiator Hose

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-upper-radiator-hose.html

How to Replace a Lower Radiator Hose

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-lower-radiator-hose.html

How to Replace a Timing Belt?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-timing-belt.html

How to Check for Loose or Worn Suspension

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-for-loose-or-worn.html

How to Check for Loose Steering System

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-for-loose-steering-system.html

How to Replace an Oil Pressure Switch (Sensor)

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-oil-pressure-switch.html

How to Replace a Fender Liner or Splash Shield

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fender-liner-or-splash.html

How to Replace a Hood Insulator

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-hood-insulator.html

How to Replace a Rear Differential.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-differential.html

How to Repair a Hood Hinge

http://schematicsdiagram.blogspot.com/2011/07/how-to-repair-hood-hinge.html

How to Replace a Brake Pedal Return Spring

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-brake-pedal-return.html

How to Replace a Door Shell.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-door-shell.html

How to Replace a Transfer Case Front Output Seal

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-transfer-case-front.html

How to Replace a Hood Latch/Lock Assembly

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-hood-latchlock-assembly.html

How to Replace a Lift Gate Strut

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-lift-gate-strut.html

How to Replace Mud Flaps (Mud Guards)

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-mud-flaps.html

How to Check Differential Oil Leaks and Replace Oil.

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-differential-oil-leaks-and.html

How to Replace a Mirror

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-mirror.html

How to Replace a Transfer Case Shift Linkage

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-transfer-case-shift.html

How to Replace a Transmission Mount

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-transmission-mount.html

How to Replace a U-Joint

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-u-joint.html

How to Replace a Washer Tank

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-washer-tank.html

How to Replace an A/C Line or Hose

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-ac-line-or-hose.html

How to Replace a Heater and A/C Blower Motor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-heater-and-ac-blower.html

How to Replace an ABS Control Unit

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-abs-control-unit.html

How to Perform a Brake Adjustment

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-brake-adjustment.html

How to Replace an Alternator Belt

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-alternator-belt.html

How to Replace an Emblem

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-emblem.html

How to Replace an Exhaust Manifold Gasket

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-exhaust-manifold-gasket.html

How to Replace a Tail Pipe

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tail-pipe.html

How to Replace Shock Absorbers

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-shock-absorbers.html

How to Replace a Strut Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-strut-assembly.html

How to Replace a Driveshaft

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-driveshaft.html

How to Replace a Wheel Cylinder

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-wheel-cylinder.html

How to Replace a Hood

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-hood.html

How to Replace a Brake Disc (Rotor)

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-brake-disc-rotor.html

How to Replace a Metal License Plate Bracket

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-metal-license-plate.html

How to Replace a Power Steering Pump

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-power-steering-pump.html

How to Perform a Basic Engine Tune-Up

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-basic-engine-tune-up.html

How to Perform a Basic Engine Tune Up-Oil Change

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-basic-engine-tune-up-oil.html

How to Perform a Basic Engine Tune Up-Spark Plug and Wire Change

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-basic-engine-tune-up_01.html

How to Replace a Distributor Cap and Rotor ?

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-distributor-cap-and.html

How to Repair a Valance

http://schematicsdiagram.blogspot.com/2011/08/how-to-repair-valance.html

How to Replace a Turn Signal Switch

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-turn-signal-switch.html

How to Replace a Plastic Bumper Cover

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-plastic-bumper-cover.html

How to Replace a Parking Brake Cable

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-parking-brake-cable.html

How to Replace Windshield Wiper Blade Refills

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-windshield-wiper-blade.html

How to Replace a Corner Light

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-corner-light.html

How to Replace a Bumper Bracket or Side Support

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-bumper-bracket-or-side.html

How to Replace a Washer Pump.

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-washer-pump.html

How to Replace a Grille

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-grille.html

How to Replace a Locking Hub

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-locking-hub.html

How to Replace a Fender

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fender.html

How to Replace a Power Steering Hose

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-power-steering-hose.html

How to Replace a Tailgate

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tailgate.html

How to Replace a Soft Top

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-soft-top.html

How to Replace a Carburetor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-carburetor.html

­

How to Replace a Bumper Trim

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-bumper-trim.html

How to Replace Trunk Strut

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-trunk-strut.html

How to Replace a Front End Cover

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-front-end-cover.html

How to Replace a Front Pipe

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-front-pipe.html

How to Replace an Antenna Mast

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-antenna-mast.html

How to Replace a Side Marker Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-side-marker-light.html

How to Install a Carpet on car?

http://schematicsdiagram.blogspot.com/2011/08/how-to-install-carpet-on-car.html

How to Replace a Spoiler

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-spoiler.html

How to Replace a Mirror Glass on car?

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-mirror-glass-on-car.html

How to Replace a Step Bumper?

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-step-bumper.html

How to Replace a Door Lock

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-door-lock.html

How to Replace a Throttle Body

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-throttle-body.html

How to Replace a Throttle Position Sensor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-throttle-position-sensor.html

How to Replace a Grille Insert

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-grille-insert.html

How to Replace a Fan Shroud Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fan-shroud-assembly.html

How to Replace an Engine Splash Shield

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-engine-splash-shield.html

How to Replace a Turn Signal Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-turn-signal-light.html

How to Replace a Headlight Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight-assembly.html

How to Replace a Park Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-park-light-assembly.html

How to Replace an Expansion Tank

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-expansion-tank.html

How to Replace an Exhaust System

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-exhaust-system.html

How to Replace a Fender Trim

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fender-trim.html

How to Replace a Headlight Door

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight-door.html

How to Replace a Fan Shroud

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fan-shroud.html

How to Replace a Harmonic Balancer

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-harmonic-balancer.html

How to Replace a Header Panel

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-header-panel.html

How to Replace a Fuel Tank

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fuel-tank.html

How to Replace a Fuel Tank Cap

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fuel-tank-cap.html

How to Replace a Distributor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-distributor.html

How to Replace an EGR Valve

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-egr-valve.html

How to Replace an Oxygen Sensor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-oxygen-sensor.html

How to Replace an Ignition Wire Set

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-ignition-wire-set.html

How to Replace a Tail Light

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tail-light.html

How to Replace a Door Handle

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-door-handle_18.html

How to Replace a Hood Strut

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-hood-strut.html

How to Replace Tail Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tail-light-assembly.html

How to Replace a Front Bumper

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-front-bumper.html

How to Replace a Fuel Pump Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fuel-pump-assembly.html

How to Replace an Axle Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-axle-assembly.html

How to Replace a Tailgate Handle

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tailgate-handle.html

How to Replace a Wheel Hub Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-wheel-hub-assembly.html

How to Replace a Control Arm

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-control-arm.html

How to Replace a Window Regulator with Motor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-window-regulator-with.html

How to Replace a Headlight

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight.html

How to Check the Brake Fluid Level

http://schematicsdiagram.blogspot.com/2011/08/how-to-check-brake-fluid-level.html

How to Replace a Parking Brake Switch

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-parking-brake-switch.html

How to Replace a Blower Motor Resistor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-blower-motor-resistor.html

How to replace frost plug on car?

http://howtobyme.blogspot.com/2011/08/how-to-replace-frost-plug-on-car.html

Horn stopped working?

http://howtobyme.blogspot.com/2011/08/horn-stopped-working.html

How to clean egr valve on Isuzu Amigo?

http://howtobyme.blogspot.com/2011/08/how-to-clean-egr-valve-on-isuzu-amigo.html

Cruise control stopped working?

http://howtobyme.blogspot.com/2011/08/cruise-control-stopped-working.html

Car is stuck in park and the shift will not move?

http://howtobyme.blogspot.com/2011/08/car-is-stuck-in-park-and-shift-will-not.html

How to change the outer door weather strip?

http://howtobyme.blogspot.com/2011/08/how-to-change-outer-door-weather-strip.html

Car slows down when it gets hotter?

http://howtobyme.blogspot.com/2011/08/car-slows-down-when-it-gets-hotter.html

Warning lights on and speedometer died?

http://howtobyme.blogspot.com/2011/08/warning-lights-on-and-speedometer-died.html

Car won't rev past 1900 rpms?

http://howtobyme.blogspot.com/2011/08/car-wont-rev-past-1900-rpms.html

No comments:

Post a Comment