Monday, November 26, 2012

OBD Code P1490 low speed fan relay ckt open-short


No Coolant Fan running on Chrysler Vehicle


When these problem occurs you get OBD code P1490



These coolant  fan has 2 speeds. High and low speeds. These speeds are controlled by its respective relays.There are two relays.One controls high and other controls low.
There are 3 wires at the fan motor. One is ground for both fan motor speeds and the other 2 are for the high and low speeds.
To confirm the problem try these give 12 volt power from another battery source like from cig lighter or from fuse connector or from battery positive supply.Run a direct wire from 12 volt source to the fan supply wire and see if the fan starts running or not.

You have to supply power to one of the speeds and see if the fan works. You can verify it by checking the other speed as well to insure it does work on one of the speeds and that you are checking it correctly. If one of the speeds does not work then the fan will need to be replaced.

See below coolant fan and fan relay wiring diagram :-----


The yellow wire is the high speed and the green is the low speed.
Give power to each wire one by one and see if fan runs on both sped or not.It should run,if its not running then faulty fan.If it runs then its confirm that actual fan wiring is short or faulty in between.So you can get it rewired to solve the problem.


Chrysler cooling fan wiring diagram



These diagram will help.
Thanks.


DIC says "COOLING FAN FAULT"?

http://schematicsdiagram.blogspot.com/2011/12/dic-says-cooling-fan-fault.html


How to replace Cooling Fan on Acura Car models?

                                        

Engine cooling components working?

               

How does Vehicles Engine cooling system works?


Hyundai Sonata cooling fan not working

http://schematicsdiagram.blogspot.in/2012/02/hyundai-sonata-cooling-fan-not-working.html

Fuel pump relay and cooling fan relay troubleshooting on 1997 ford thunderbird?

http://repairhelpcenter.blogspot.com/2011/10/fuel-pump-relay-and-cooling-fan-relay.html


Cooling Fan Stays ON with Ignition Off?

http://whatisbyme.blogspot.in/2012/07/cooling-fan-stays-on-with-ignition-off.html


Engine makes noise and Cooling Fan belt Breaks?

http://howtobyme.blogspot.com/2011/12/engine-makes-noise-and-cooling-fan-belt.html


Replace Fan Relay but still Radiator cooling fans not working?

http://schematicsdiagram.blogspot.com/2011/12/replace-fan-relay-but-still-radiator.html


Toyota Celica: Cooling fan Shuts OFF and Idle Drops?

http://howtobyme.blogspot.in/2012/05/toyota-celica-cooling-fan-shuts-off-and.html


Cooling fan relays location on 1998 ford mustang?

http://technoanswers.blogspot.in/2012/02/cooling-fan-relays-location-on-1998.html





No comments:

Post a Comment